|
|
03-30-2005, 05:25 PM
|
#1
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
Still No Start
still no luck with my TPI conversion. installed new TPI fuel pump and it works, plenty of presure. car cranks and keeeps crakin. its puffs pops and hisses and small clouds of smoke come out of the TPI plenum and the runners are gettin warm but she just wont start. could it be crossed ignition wires? maybe the dist? also i ****ed up the fuel tank fill tube while takin it out, i bent it all up n now the tank wont sit right. anybody got a tank layin around without a bent fill tube i guess
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
03-31-2005, 08:28 AM
|
#2
|
Co-Founder / Site Admin
Join Date: Jul 2004
Location: Ewing, NJ
Posts: 22,473
|
Are you sure that the distributor is in correctly? It could be 180* out if it's cranking and blowing smoke out the top.
- Justin
__________________
1999 Camry - Beigemobile DD
2002 Suburban - Wife's DD
2004 Grand Cherokee - Not running / Project / Selling?
|
|
|
03-31-2005, 08:29 AM
|
#3
|
14 Second Club
Join Date: Aug 2004
Location: RUM$ON, NJ
Posts: 2,308
|
Quote:
Originally Posted by Tru2Chevy
Are you sure that the distributor is in correctly? It could be 180* out if it's cranking and blowing smoke out the top.
- Justin
|
Yeah. Try popping the cap 180* around.
Also, are you sure that you marked where the rotor was on the dist and put it back the same way?
__________________
Quote:
Originally Posted by The Fapist
K0ll is a hick and has a veritable fleet of 1980-early 90's GM vehicles :mullet:
|
|
|
|
03-31-2005, 08:33 AM
|
#4
|
Join Date: Aug 2004
Location: North Jersey
Posts: 3,047
|
Agreed with Justin. If you wanna check it the easy way, find where #6 is on the cap, and make that #1. Then re-wire from that point. That would be the same as pulling the distributor.
__________________
Seeya,
Steve R. in North Jersey
'16 Go-Mango Dodge Charger R/T. It's so good to be back in a V8-powered, RWD car!
Former Toy - '88 Monte SS - had lots of mods...
|
|
|
03-31-2005, 11:50 AM
|
#5
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
ok steve ur idea worked, but only once, on the second start i got nothin but a click from wat sounds like the area of the dist, so i put the plugs back to the correct spots and still jus the click....
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
03-31-2005, 12:01 PM
|
#6
|
Co-Founder / Site Admin
Join Date: Jul 2004
Location: Ewing, NJ
Posts: 22,473
|
Quote:
Originally Posted by maroman88
ok steve ur idea worked, but only once, on the second start i got nothin but a click from wat sounds like the area of the dist, so i put the plugs back to the correct spots and still jus the click....
|
Did it actually start up and run?
- Justin
__________________
1999 Camry - Beigemobile DD
2002 Suburban - Wife's DD
2004 Grand Cherokee - Not running / Project / Selling?
|
|
|
03-31-2005, 12:04 PM
|
#7
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
yea for about 3 seconds lol
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
03-31-2005, 12:06 PM
|
#8
|
Co-Founder / Site Admin
Join Date: Jul 2004
Location: Ewing, NJ
Posts: 22,473
|
Quote:
Originally Posted by maroman88
yea for about 3 seconds lol
|
Well if it actually ran then why did you change it back? Look for whatever is causing your new problem next....
- Justin
__________________
1999 Camry - Beigemobile DD
2002 Suburban - Wife's DD
2004 Grand Cherokee - Not running / Project / Selling?
|
|
|
03-31-2005, 12:14 PM
|
#9
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
i looked, the click seems to be coming from the distibuter but ill have to take a better look between school and work later today. i know its not the starter clicking cuz my other camaro makes that noise all the time. ill check all the fuses but i have no idea what could cause it to just click?
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
03-31-2005, 02:38 PM
|
#10
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
ok the click has been narrowed down to either the EGR(the circle in the middle of the manifold) or the cold start 9th injector. i have no idea wat the EGR is or does and if it would cause this so please help!?
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
03-31-2005, 03:16 PM
|
#11
|
Join Date: Aug 2004
Location: Hillsborough, NJ
Posts: 2,630
|
I'd say your timing is still off enough to keep it from running. Pull the distributor out and pull the driver valve cover. Turn your engine over until the balancer mark is lined up with 0 on the timing tab and both of the valves for #1 are closed. Then line everything up so the distributor drops back down with the rotor pointing at the correct number 1 position (about 5 o'clock). Then reinstall your cap and wires correctly and crank it up. Should be close enough to keep it running now and then fine tune it with a timing ligh.
__________________
--==RPM Resto & Custom==--
1989 IROC-Z Media Coverage:
Chevy High Performance - Readers Rides 4/03
GM High Tech Performance - Tech Article 3/06
Chevy Rumble - Tech & Feature Articles November 2006
Auto Restorer Magazine - Feature Article 5/11
SkinAndSteel.com
|
|
|
04-01-2005, 01:46 PM
|
#12
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
as of now the engine wont turn over, when u turn the key there is just a small click that might be coming from the EGR
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-01-2005, 04:24 PM
|
#13
|
Join Date: Aug 2004
Location: North Jersey
Posts: 3,047
|
Could it be something wrong with the VATS unit?
__________________
Seeya,
Steve R. in North Jersey
'16 Go-Mango Dodge Charger R/T. It's so good to be back in a V8-powered, RWD car!
Former Toy - '88 Monte SS - had lots of mods...
|
|
|
04-01-2005, 04:54 PM
|
#14
|
Join Date: Aug 2004
Location: Montgomery NJ
Posts: 1,271
|
Quote:
Originally Posted by maroman88
as of now the engine wont turn over, when u turn the key there is just a small click that might be coming from the EGR
|
Sounds like a battery problem. Try jumping it and see if it turns over.
__________________
, Jon
Owner of a Red Sled.
If it\'s EFI I can tune it. Specialize in 82-95 GM (yes Lt1\'s)
\"If you can leave black marks on a straight from the time you exit a corner till the time you brake for the next turn.......Then, you have enough horsepower\" - Mark Donohue
|
|
|
04-01-2005, 05:26 PM
|
#15
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
no vats on the 88 and the battery seems fine, plenty of fuel pressure, 9th injector is workin, just that click that seems to be soming from the EGR valve and thats it. even when u turn the key with the cap and all the wires off thats still all that happens
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-01-2005, 07:06 PM
|
#16
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
keep in mind it did run yesterday for a very short period, then after that nothing... could the EGR be stuck closed/open, i tested it like it said to do in the maual, i pushed on the inside and it made a suction feeling and could hear the air moving, im stuck........................
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-02-2005, 01:15 PM
|
#17
|
Co-Founder / Site Admin
Join Date: Jul 2004
Location: Ewing, NJ
Posts: 22,473
|
So when you turn the key now, it clicks, and nothing else?
Bad starter/solenoid? I say bust out the voltmeter (or even test light) and see if everything is getting power.
- Justin
__________________
1999 Camry - Beigemobile DD
2002 Suburban - Wife's DD
2004 Grand Cherokee - Not running / Project / Selling?
|
|
|
04-02-2005, 03:23 PM
|
#18
|
Join Date: Mar 2005
Location: Bridgewater NJ
Posts: 432
|
Check the Pick up on the distributor or the Module...that little black rectangle on the dist. might be shot.....Part might run 50 bucks. If you haven't already tired Take wire #1 stick a screwdriver in it... put it a 1/4 inch or closer to a piece of metal & have someone turn the key just with short cranks...if no spark you problem is the pick up and module.
__________________
Paul
87 Camaro Z28
09 Cobalt XFE
|
|
|
04-03-2005, 01:25 AM
|
#19
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
ive got another distibutor so when it stops raining ill pop that in and see if it does anything different, i just rechecked all the wires to the starter and gave it a good smack lol
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-04-2005, 07:46 AM
|
#20
|
Join Date: Aug 2004
Location: Hillsborough, NJ
Posts: 2,630
|
Definitly electrical. The EGR cannot make a clicking sound as it's a rubber diaphragm inside.
__________________
--==RPM Resto & Custom==--
1989 IROC-Z Media Coverage:
Chevy High Performance - Readers Rides 4/03
GM High Tech Performance - Tech Article 3/06
Chevy Rumble - Tech & Feature Articles November 2006
Auto Restorer Magazine - Feature Article 5/11
SkinAndSteel.com
|
|
|
04-04-2005, 03:49 PM
|
#21
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
i swapped the little black rectangle thing with another one and nothing, so i swapped the whole distibutor and still nothing, where is the starter solinoid? by the starter?
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
04-04-2005, 07:46 PM
|
#22
|
Join Date: Aug 2004
Location: Hillsborough, NJ
Posts: 2,630
|
It's bolted right to the starter.
__________________
--==RPM Resto & Custom==--
1989 IROC-Z Media Coverage:
Chevy High Performance - Readers Rides 4/03
GM High Tech Performance - Tech Article 3/06
Chevy Rumble - Tech & Feature Articles November 2006
Auto Restorer Magazine - Feature Article 5/11
SkinAndSteel.com
|
|
|
04-04-2005, 07:48 PM
|
#23
|
Banned Camp Director Emeritus
Join Date: Aug 2004
Location: Somerset County
Posts: 8,395
|
the starter solenoid is ON the starter.
__________________
Quote:
Originally Posted by baddest434
and 1 more smart ass answer by you and i'm going to reach into this monitor and grab you by the throat
|
|
|
|
04-04-2005, 09:10 PM
|
#24
|
Join Date: Mar 2005
Location: Bridgewater NJ
Posts: 432
|
did you place the electrod jelly under the module....i did that too and i fried a new one. theres a special electrode jelly that needs to be spread under the module on the metal side. With out that coated on there once you turn the key ur screwed....or u might get one start out of it.....take the distributor that u have and get a new pick up and module because after i fried the module the pick up went bad and i needed a new pick up and module.....your last crank was probably all you had left on the pick up. change out the module and pick up....or else its like using a condom twice with out changing the pick up
__________________
Paul
87 Camaro Z28
09 Cobalt XFE
|
|
|
04-04-2005, 11:05 PM
|
#25
|
12 Second Club
Join Date: Aug 2004
Location: Oradell
Posts: 8,368
|
electrod jelly? where do i get that? there was no jelly of any sort on either distibutor and the 1st one was on the car with the TBI system i had before n it was fine, and the new one was working out of a 88 GTA. if its not the starter or solinoid ill try the pickup or module, are they 2 seperate things? the module i swapped had the connectors for the 2 electrical plugs n thta was all that looked like it could come off.
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
|
|