Today's Posts Mark Forums Read Calendar
Go Back   NJFBOA - Home of New Jersey's Camaros and Firebirds > Camaros, Firebirds and the People that own them > Member's Projects

Notices


Reply
 
Thread Tools
Old 05-13-2014, 11:20 PM   #1
TaKid455
 
Join Date: Oct 2008
Posts: 586
iTrader: (1)
1978 T/A auto to manual conversion w/ Day 2 mods. Marty's transformation.

Haven’t posted a project in a bit so here an interesting one t hat will also answer many questions other many have regarding auto to manual swaps, transmission selection, exhaust modifications, carb and distributor tuning.
Had the opportunity to transform a car’s personality from nice leisure cruiser to gear banging spirited driver. This T/A has some prior internet fame going by the name ‘Marty’ primarily the abbreviated of the Martinique Blue color name. Intent was to ‘wake up’ the car and swap the transmission from the stock TH350 to a Richmond/ Doug Nash 5 speed all while retaining a stock appearance. The changes could also be considered ‘Day 2’ mods such as Mecham Pontiac of DKM/ Macho T/A fame would perform on new T/A’s back in the day.
Subject:
1978 T/A
WS6, 400 L78, auto, 2.56 rear, 31k miles. Very clean and well preserved car.






For the Factory markings people



Factory service dept ‘test pipe’. This was installed to test if the catalytic converter was faulty. Some were installed to test and were ‘forgotten’ to be removed.



Even with careful scraping, colors of stripes are undistinguishable.
36 year old underside. Oil pan should be painted. This pan was removed in its prior history for reasons unknown.




With the Th350 & exhaust removed, one can see additional factory markings


Some stuff that fell out of the car. All but the driveshaft will be shelved safely for originality purposes and not discarded. D-shaft will be reused.



New ceramic coated 2.5” RARE manifolds

All parts required for a complete auto to manual swap for St-10 4 speed or DN 5 speed. TKO’s and T56s will have some different parts but interior parts will be the same. Pictured is the Richmond 5speed or commonly referenced as Doug Nash 4+1.




Since we were there and it was leaking, the oil pan gasket was replaced w/ a 1 piece gasket. Pan and engine was touched up w/ GM corporate blue but saving original color markings. Inside a 31k mile engine

Conversion begins to take place




Manifolds and clutch linkage

New look




Better breathing. 2.5” all the way.

Tips in factory position as car was received.


Console before

After

Peak a boo

Installed w/ all factory or factory repop 4 speed parts



Carb rejected for richer mixture both primaries and secondaries and distributor recurved so all 36 deg of timing advance comes in by 2800 rpm.
Overall the job was a success. Car has changed personalities for the better and is much livelier and has decent pick up. Even with the 2.56 rear end gears thanks to the transmission’s deep 3.27 first gear. Fifth is still 1:1 so the high gear in the back is needed. Most run 2.73 or 3.08 for road courses but this application was perfectly fine with the OE set.
TaKid455 is offline   Reply With Quote
Old 05-14-2014, 02:56 PM   #2
maroman88
12 Second Club
 
maroman88's Avatar
 
Join Date: Aug 2004
Location: Oradell
Posts: 8,367
iTrader: (11)
wow, that's beautiful
__________________
86 Camaro
88 Camaro
95 Impala SS
97 Trans Am WS6
98 Blazer ZR2
00 Corvette
04 CTS-V
07 Sublime Charger Daytona
10 Tahoe SSV
12 Tahoe LT
17 Malibu LT
maroman88 is offline   Reply With Quote
Old 05-14-2014, 08:51 PM   #3
The Fixer
 
The Fixer's Avatar
 
Join Date: Aug 2004
Location: North Jersey
Posts: 3,047
iTrader: (5)
Great job - looks factory, and I'm sure feels like a different car now that you can row your own gears! Love the color too, that's not one you see very often.
__________________
Seeya,
Steve R. in North Jersey
'16 Go-Mango Dodge Charger R/T. It's so good to be back in a V8-powered, RWD car!

Former Toy - '88 Monte SS - had lots of mods...
The Fixer is offline   Reply With Quote
Reply

  NJFBOA - Home of New Jersey's Camaros and Firebirds > Camaros, Firebirds and the People that own them > Member's Projects

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

» Sponsor List














All times are GMT -5. The time now is 08:13 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.